KLEAN-STRIP Goof Off Pro Strength Overspray Remover
Priced as of May 16, 2026
4.2(40 ratings)Buy on AmazonSaved to your guest loadout. Sign up to also save to your Cabinet (consumables) or Kit (tools you own).
As an Amazon Associate and affiliate partner, CarCareTruth earns from qualifying purchases. Full disclosure
Prices may varyFrom the Safety Data Sheet
Full SDS ↗ (rev. 2020-02-10)GHS hazard codes are quoted from the manufacturer’s Safety Data Sheet. PPE tiers below translate those codes and the listed ingredient chemistry; they are not CarCareTruth recommendations.
EyesSituationalMfr. SDS §8 · 29 CFR 1910.133(a)(1) · GHS H319SkinRecommendedMfr. SDS §8LungsRecommendedMfr. SDS §8 · 29 CFR 1910.1000 · GHS H340Ventilation—No PPE in published sourcesShow details for all categories ▾Hide details ▴
From the manufacturer’s Safety Data Sheet, Section 8
“H319 (eye irritation Cat 2A) in SDS §2. Aerosol format creates mist during dispensing — risk of eye contact when spraying onto cloth at close range. SDS §8 specifies chemical goggles.”
— KLEAN-STRIP
U.S. regulatory standard
29 CFR 1910.133(a)(1)
“The employer shall ensure that each affected employee uses appropriate eye or face protection when exposed to eye or face hazards from… liquid chemicals…”
ANSI Z87.1 (incorporated via §1910.6)
OSHA standards apply to workplaces. Cited here as the U.S. reference threshold for the underlying hazard class.
CarCareTruth publishes the cited sources verbatim and does not advise what action a user should take. Consult the full SDS before use.
From the manufacturer’s Safety Data Sheet, Section 8
“SDS §8 specifies rubber or nitrile gloves. H315 (skin irritation) is implied by the solvent chemistry (acetone, xylene, mineral spirits) at the concentrations in §3; wiping contact with solvent-laden cloth creates sustained skin exposure. SDS explicitly warns this product can be absorbed through skin.”
— KLEAN-STRIP
CarCareTruth publishes the cited sources verbatim and does not advise what action a user should take. Consult the full SDS before use.
From the manufacturer’s Safety Data Sheet, Section 8
“H335 (respiratory irritation, STOT SE Cat 3) in SDS §2 plus aerosol format. Aerosol dispensing creates inhalable vapor at close range. SDS §8 specifies NIOSH-approved organic vapor cartridge respirator when exposure limits cannot be controlled. SDS §8 also warns: 'If strong odor is noticed or you experience slight dizziness, headache, nausea or eye-watering — STOP — ventilation is inadequate.'”
— KLEAN-STRIP
U.S. regulatory standard
29 CFR 1910.1000; 1910.1200
“Each employer shall assure that no employee is exposed to an inhalation concentration of any substance shown in Tables Z-1, Z-2, or Z-3 in excess of the limits in the tables.”
OSHA standards apply to workplaces. Cited here as the U.S. reference threshold for the underlying hazard class.
CarCareTruth publishes the cited sources verbatim and does not advise what action a user should take. Consult the full SDS before use.
The published Safety Data Sheet for this product does not specify ventilation protection for consumer use.
Workplace context
29 CFR 1910.134(a); 1910.1000
“the primary objective shall be to prevent atmospheric contamination [via] accepted engineering control measures (for example, enclosure or confinement of the operation, general and local ventilation, and substitution with less toxic materials).”
Triggered by GHS H335 on the SDS.
OSHA standards apply to workplaces. Cited here as the U.S. reference threshold for the underlying hazard class.
PPE tiers translate the manufacturer’s SDS and U.S. regulatory standards. Not professional safety advice. How we report safety.
CarCareTruth's Analysis
Last reviewed May 16, 2026
TL;DR Removes dried road paint and clearcoat/basecoat overspray from cured OEM paint in a few wipes. The acetone-dominant aerosol carries a DANGER signal word driven by germ cell mutagenicity (H340) and a Prop 65 warning for ethylbenzene. Health score: 3.1/10. Keep it off plastic trim; use outdoors with gloves and ventilation.
What it is and how it performs
Goof Off Pro Strength Overspray Remover is a 12 oz aerosol applied onto a cloth for a wipe-on, wipe-off workflow. The acetone-heavy formula dissolves bonded road paint without abrasion — an AutoGeek forum user removed yellow road paint accumulated over 1.5 years across an entire vehicle side in under 30 minutes. Brand coverage: dried road paint, basecoat, and clearcoat overspray on fully cured OEM surfaces and glass. The manufacturer's label warns the product damages many plastics, worn vinyl, and some automotive paints — keep it off trim.
Who should buy this — and who should skip it
Right for a vehicle hit by road-paint or construction overspray that survived a wash and clay session untouched. Skip for fresh water-based overspray — clay with lubricant avoids solvent exposure entirely. Also skip anywhere plastic bumper trim, rubber moldings, or vinyl surfaces are in the treatment zone.
Safety and environmental impact
Signal word DANGER is driven by H340 (germ cell mutagenicity Cat 1A) and H351 (suspected carcinogen Cat 2). Ethylbenzene (1–5%) is the Prop 65-listed carcinogen per SDS §15. H335 (respiratory irritation) applies in aerosol format; SDS §8 requires outdoor or cross-ventilated use and specifies nitrile gloves — formula is absorbed through skin. Estimated VOC exceeds 550 g/L; SDS §13 classifies this as hazardous waste.
Frequently asked questions
Is Goof Off Overspray Remover safe on ceramic coatings or paint protection film?▾
The SDS does not confirm compatibility with ceramic coatings or PPF. The manufacturer specifies use only on 'fully cured OEM surfaces and hard non-porous surfaces' — not on aftermarket coatings or film. The acetone-dominant solvent chemistry carries risk for any coating that is not fully cross-linked. There is no independent community confirmation of coating or PPF safety.
Can Goof Off Overspray Remover damage plastic trim?▾
Yes — the manufacturer's label explicitly states the product 'Damages many plastics, worn vinyl floors, some automotive paints, and some carpets.' Forum users have reported permanent staining of plastic mirror housings and trim. Keep the product off all plastic and rubber surfaces during application.
Does Goof Off Overspray Remover have a Prop 65 warning?▾
Yes. The back-of-bottle label carries a California Proposition 65 warning for cancer. The SDS §15 identifies ethylbenzene (1–5% of the formula) as the Prop 65-listed carcinogen. The warning applies to California residents; standard safety precautions — outdoors use, ventilation, gloves — apply everywhere.
What types of overspray does this product remove?▾
The brand markets this product for dried road paint, dried clearcoat and basecoat overspray, and construction spray on fully cured OEM surfaces. Community evidence confirms effectiveness on yellow road paint that has dried for over a year. Industrial epoxy or powder-coat overspray is not documented.
From the manufacturer
Marketing copy from KLEAN-STRIP, via Amazon. Not editorial.
- •Pro Strength Remover: Easily removes dried clearcoat and basecoat overspray from automotive surfaces and glass.
- •Fast-Acting Formula: Works quickly to cut through tough paint overspray mistakes, saving you time and effort.
- •Versatile Use: Ideal for use around collision centers, garages, and workshops on fully cured OEM and hard non-porous surfaces.
- •Cost-Effective Solution: More economical and effective than using a claybar for removing dried road paint and latex paint.
- •Safe Application: Apply with a cloth on recommended surfaces; wear safety goggles and solvent-resistant gloves for best results.
Weekly pick
One product, one safety verdict, every week. No spam.
Manufacturer images
Manufacturer specifications
- Brand
- KLEAN-STRIP
- Item Volume
- 12 Fluid Ounces
- Unit Count
- 1.0 Count
- Surface Recommendation
- Glass
- Number of Items
- 1
- Contains Liquid Contents?
- Yes
- Brand Name
- KLEAN-STRIP
- Manufacturer
- Barr
- UPC
- 093945398219
- Part Number
- FG821
- Best Sellers Rank
- #80,722 in Automotive (See Top 100 in Automotive) #10 in Automotive Paint Remover & Stripper
- ASIN
- B08LP7VFFZ
More in Overspray Remover
Sunnyside Corporation
Ready-Strip Paint Overspray & Spatters Remover
CCT 6.7 · DecentHealth 9.5
Mötsenböcker's Lift Off
Paint Scuff and Graffiti Remover
NO SDSCCT 5.6 · Decent
As an Amazon Associate and affiliate partner, CarCareTruth earns from qualifying purchases. Full disclosure
Community
0 postsShare how you use this product
Drop a quick comment or post a full review with photos and a star rating.
Sign in to postNew here? Create a free account.
Top Amazon review
↗External — Amazon's most-helpful review for context.